Process can use coal, shale gas and biomass while consuming carbon dioxide
Engineers at The Ohio State University are developing technologies that have the potential to economically convert fossil fuels and biomass into useful products including electricity without emitting carbon dioxide to the atmosphere.
In the first of two papers published in the journal Energy & Environmental Science, the engineers report that they’ve devised a process that transforms shale gas into products such as methanol and gasoline—all while consuming carbon dioxide. This process can also be applied to coal and biomass to produce useful products.
In the second paper, they report that they’ve found a way to greatly extend the lifetime of the particles that enable the chemical reaction to transform coal or other fuels to electricity and useful products over a length of time that is useful for commercial operation.Under certain conditions, the technology consumes all the carbon dioxide it produces plus additional carbon dioxide from an outside source.
Finally, the same team has discovered and patented a way with the potential to lower the capital costs in producing a fuel gas called synthesis gas, or “syngas,” by about 50 percent over the traditional technology.
The technology, known as chemical looping, uses metal oxide particles in high-pressure reactors to “burn” fossil fuels and biomass without the presence of oxygen in the air. The metal oxide provides the oxygen for the reaction.
Chemical looping is capable of acting as a stopgap technology that can provide clean electricity until renewable energies such as solar and wind become both widely available and affordable, the engineers said.
“Renewables are the future,” said Liang-Shih Fan, Distinguished University Professor in Chemical and Biomolecular Engineering, who leads the effort. “We need a bridge that allows us to create clean energy until we get there—something affordable we can use for the next 30 years or more, while wind and solar power become the prevailing technologies.”
Five years ago, Fan and his research team demonstrated a technology called coal-direct chemical looping (CDCL) combustion, in which they were able to release energy from coal while capturing more than 99 percent of the resulting carbon dioxide, preventing its emission to the environment. The key advance of CDCL came in the form of iron oxide particles which supply the oxygen for chemical combustion in a moving bed reactor. After combustion, the particles take back the oxygen from air, and the cycle begins again.
The challenge then, as now, was how to keep the particles from wearing out, said Andrew Tong, research assistant professor of chemical and biomolecular engineering at Ohio State.
While five years ago the particles for CDCL lasted through 100 cycles for more than eight days of continuous operation, the engineers have since developed a new formulation that lasts for more than 3,000 cycles, or more than eight months of continuous use in laboratory tests. A similar formulation has also been tested at sub-pilot and pilot plants.
“The particle itself is a vessel, and it’s carrying the oxygen back and forth in this process, and it eventually falls apart. Like a truck transporting goods on a highway, eventually it’s going to undergo some wear and tear. And we’re saying we devised a particle that can make the trip 3,000 times in the lab and still maintain its integrity,” Tong said.
This is the longest lifetime ever reported for the oxygen carrier, he added. The next step is to test the carrier in an integrated coal-fired chemical looping process.
Another advancement involves the engineers’ development of chemical looping for production of syngas, which in turn provides the building blocks for a host of other useful products including ammonia, plastics or even carbon fibers.
This is where the technology really gets interesting: It provides a potential industrial use for carbon dioxide as a raw material for producing useful, everyday products.
Today, when carbon dioxide is scrubbed from power plant exhaust, it is intended to be buried to keep it from entering the atmosphere as a greenhouse gas. In this new scenario, some of the scrubbed carbon dioxide wouldn’t need to be buried; it could be converted into useful products.
Taken together, Fan said, these advancements bring Ohio State’s chemical looping technology many steps closer to commercialization.
He calls the most recent advances “significant and exciting,” and they’ve been a long time coming. True innovations in science are uncommon, and when they do happen, they’re not sudden. They’re usually the result of decades of concerted effort—or, in Fan’s case, the result of 40 years of research at Ohio State. Throughout some of that time, his work has been supported by the U.S. Department of Energy and the Ohio Development Services Agency.
“This is my life’s work,” Fan said.
Learn more: A fossil fuel technology that doesn’t pollute
The Latest on: Chemical looping
- Topology Gets Magnetic: The New Wave Of Topological Magnetic Materialson November 23, 2020 at 8:32 pm
The electronic structure of nonmagnetic crystals can be classified by complete theories of band topology, reminiscent of a “topological periodic table.” However, such a classification for magnetic ...
- Green shoots: DyeMansion and the Green Deal Recoveryon November 23, 2020 at 5:00 am
AM post-processing specialist DyeMansion on being one of the first companies on board Europe's mission to become the first climate-neutral continent.
- Audi and KIT are working on recycling method for automotive plasticson November 23, 2020 at 2:41 am
Whereas plastics of the same type can often be mechanically recycled, recycling of mixed plastic waste poses a major challenge. Audi and the Karlsruhe Institute for Technology (KIT) are therefore ...
- 3 injured in collision at Quaker & North Loopon November 21, 2020 at 7:23 pm
Three people suffered minor to moderate injuries in a collision at Quaker and the North Loop, briefly blocking traffic on Saturday afternoon.
- AppHarvest Plants First Tomato Crop with Harvest Expected in Grocery Stores Early Next Yearon November 20, 2020 at 1:25 am
AppHarvest today announced it has planted its first tomato crop at the company’s high-tech controlled environment agriculture facility in Morehead, Ky. The crop is scheduled to be harvested and ...
- TxDOT to close section of South Loop 289 at Quaker Avenue for repairson November 17, 2020 at 3:33 pm
The following is a press release from the Texas Department of Transportation. The Texas Department of Transportation (TxDOT) is scheduled to make repairs to the ...
- Faster pharma: Catalytic innovation combats precious metals supply chain painon November 16, 2020 at 9:25 am
Precious metal catalysts are key to pharma but subject to market forces that make reliance on supply a double-edged sword.
- Coke terminates agreement with recycling technology firm Loop Industrieson November 13, 2020 at 5:29 am
Cola Co. has terminated an agreement with embattled recycling technology company Loop Industries Inc. Montreal-based Loop reported the decision in an 8-K filed on Nov. 4 with the U.S. Securities and ...
- Loop Industries challenged by setbacks and legal strifeon November 11, 2020 at 8:39 am
Troubles are mounting for PET depolymerization startup Loop Industries. It has lost a key supply contract and also faces lawsuits and an investigation by regulators. The publicly traded, Quebec-based ...
- Mitsubishi Chemical Advanced Materials Commercializes the World's Strongest Injection Moldable Polymer Compoundson November 10, 2020 at 8:41 am
PRNewswire/ -- As the leading manufacturer of high-performance thermoplastics, Mitsubishi Chemical Advanced Materials, (MCAM) has been perfecting ...
via Google News and Bing News