Technion-Israel Institute of Technology researchers have developed a new approach to the production of hydrogen from water using solar energy. In findings published today in Nature Materials, the researchers explain that it will make possible the production of hydrogen in a safe, centralized manner at the point of sale (for example, at a gas station for electric cars fueled by hydrogen) located far from the solar farm. The new technology is expected to significantly reduce the cost of producing the hydrogen and shipping it to the customer.
The study was led by Avigail Landman, a doctoral student in the Nancy & Stephen Grand Technion Energy Program (GTEP), and Dr. Hen Dotan from the Electrochemical Materials & Devices Lab. Ms. Landman is working on her doctorate under the guidance of Prof. Avner Rothschild from the Faculty of Materials Science and Engineering, and Prof. Gideon Grader, Dean of the Faculty of Chemical Engineering.
Hydrogen is considered one of the most promising energy carriers for vehicles and various other uses because of its salient advantages:
- Hydrogen can be produced from water, and therefore production does not depend on access to non-renewable natural resources.
- Using hydrogen fuel would reduce the dependence on fossil fuels such as oil and natural gas, whose availability depends on geographical, political and other factors, and would increase the energy available to the earth’s population.
- Unlike diesel and gasoline engines that emit considerable pollution into the air, the only byproduct of hydrogen fuel utilization is water.
Because of the advantages of hydrogen fuel, many countries – led by Japan, Germany and the United States – are investing vast sums of money in programs for the development of environmentally friendly (“green”) technologies for the production of hydrogen. Most hydrogen is currently produced from natural gas in a process that emits carbon dioxide into the air, but it is also possible to produce hydrogen from water by splitting the water molecules into hydrogen and oxygen in a process called electrolysis. However, since electricity production itself is an expensive and polluting process, researchers at the Technion and around the world are developing a photoelectrochemical (PEC) cell that utilizes solar energy to split water into hydrogen and oxygen directly, without the need for external power source.
The main challenges in the development of PEC solar farms for the production of hydrogen are 1.) keeping the hydrogen and the oxygen separate from each other, 2.) collecting the hydrogen from millions of PEC cells, and 3.) transporting the hydrogen to the point of sale. The Technion team solved these challenges by developing a new method for PEC water splitting. With this method, the hydrogen and oxygen are formed in two separate cells – one that produces hydrogen, and another that produces oxygen. This is in contrast to the conventional method, in which the hydrogen and oxygen are produced within the same cell, and separated by a thin membrane that prevents them from intermixing and forming a flammable and explosive mixture.
The new process allows geographic separation between the solar farm consisting of millions of PEC cells that produce oxygen exclusively, and the site where the hydrogen is produced in a centralized, cost-effective and efficient manner. They accomplished this with a pair of auxiliary electrodes made of nickel hydroxide, an inexpensive material used in rechargeable batteries, and a metal wire connecting them.
To watch a video of the researchers explaining their new technology, click here.
“In the present article, we describe a new method for producing hydrogen through the physical separation of hydrogen production and oxygen production,” says Ms. Landman. “According to our cost estimate, our method could successfully compete with existing water splitting methods and serve as a cheap and safe platform for the production of hydrogen.”
The first diagram shows a conventional PEC device, with a membrane separating the two products (oxygen on the right, hydrogen on the left).
But that’s not all. As stated, the vision of the Technion researchers is geographic separation between the sites where the oxygen and hydrogen are produced: at one site, there will be a solar farm that will collect the sun’s energy and produce oxygen, while hydrogen is produced in a centralized manner at another site, miles away. Thus, instead of transporting compressed hydrogen from the production site to the sales point, it will only be necessary to swap the auxiliary electrodes between the two sites. Economic calculations performed in collaboration with research fellows from Evonik Creavis GmbH and the Institute of Solar Research at the German Aerospace Center (DLR), indicate the potential for significant savings in the setup and operating costs of hydrogen production.
In October, Ms. Landman won first place in the energy category in the Three Minute Thesis (3MT) competition held in Australia. At the competition, held on the initiative of the University of Queensland, participants are required to present groundbreaking research in just three minutes. Watch her lecture here.
The method developed at the Technion for separating hydrogen production and oxygen production was the basis for the development of new two-stage electrolysis technology. This technology, which was developed by Dr. Hen Dotan, enables hydrogen production at high pressure and with unprecedented efficiency, thus significantly reducing hydrogen production costs. The new technology is now in its pre-industrial development stage.
Learn more: HYDROGEN ON DEMAND
Receive an email update when we add a new HYDROGEN PRODUCTION article.
The Latest on: Hydrogen production
via Google News
The Latest on: Hydrogen production
- Global Hydrogen Electrolyzer Market 2019 to 2028 - Siemens AG, Nel Hydrogen, McPhy Energy SA, ITM Power Plc, Hydrogenics, Areva H2Gen on June 14, 2019 at 9:10 am
For hydrogen production through renewable resources, electrolysis is a promising alternative for manufacturers. In electrolysis, electricity is used to split water into oxygen and hydrogen in a system ... […]
- New IEA Report Focuses on Hydrogen Use on June 14, 2019 at 8:49 am
Reducing emissions from existing hydrogen production is a challenge but also represents an opportunity to increase the scale of clean hydrogen worldwide. One approach is to capture and store or ... […]
- IEA: hydrogen production should be scaled up for a clean energy future on June 14, 2019 at 4:31 am
The world has an important opportunity to tap into hydrogen’s vast potential to become a critical part of a more sustainable and secure energy future, the International Energy Agency (IEA) said in a ... […]
- A self-powered electrolytic process for glucose to hydrogen conversion on June 14, 2019 at 2:37 am
Glucose is a promising feedstock for hydrogen production but the existing microbial electrolysis process suffers from low efficiency. Here we show a process for hydrogen production using an integrated ... […]
- UK could use hydrogen instead of natural gas – if it can make enough on June 14, 2019 at 12:44 am
But a report by the Institution of Engineering and Technology (IET) also laid bare the huge, 10-fold increase in hydrogen production that would be needed to achieve that switch-over. Producing enough ... […]
- China Sets Sights on Hydrogen Fuel Cell Market on June 13, 2019 at 3:45 pm
... is promoting the adoption of hydrogen vehicles in selected trial regions as it sets up an ecosystem that includes hydrogen production, storage, transportation and refueling, Wan said. Long-range ... […]
- Driving a hydrogen-powered car in Denmark on June 13, 2019 at 9:27 am
Among the operators are Danish petroleum company OK and France's Air Liquide. Some 70 kilometers north of Hobro, the French run a hydrogen production facility — white containers with a corrugated ... […]
- China's Father of Electric Cars Says Hydrogen Is the Future on June 12, 2019 at 2:00 pm
In typical EVs, lithium-ion batteries store electrical energy produced away from the car and use that to power the vehicle. Hydrogen fuel cells use a chemical reaction to produce energy, converting ... […]
- Hydrogen isn’t the fuel of the future. It’s already here on June 11, 2019 at 11:35 pm
However, proven large-scale and low-emission hydrogen production is already here through hydrogen production from natural resources coupled with carbon capture and storage (CCS), a suite of ... […]
via Bing News