For decades, electronic devices have been getting smaller, and smaller, and smaller. It’s now possible—even routine—to place millions of transistors on a single silicon chip.
But transistors based on semiconductors can only get so small. “At the rate the current technology is progressing, in 10 or 20 years, they won’t be able to get any smaller,” said physicist Yoke Khin Yap of Michigan Technological University. “Also, semiconductors have another disadvantage: they waste a lot of energy in the form of heat.”
Scientists have experimented with different materials and designs for transistors to address these issues, always using semiconductors like silicon. Back in 2007, Yap wanted to try something different that might open the door to a new age of electronics.
“The idea was to make a transistor using a nanoscale insulator with nanoscale metals on top,” he said. “In principle, you could get a piece of plastic and spread a handful of metal powders on top to make the devices, if you do it right. But we were trying to create it in nanoscale, so we chose a nanoscale insulator, boron nitride nanotubes, or BNNTs for the substrate.”
Yap’s team had figured out how to make virtual carpets of BNNTs,which happen to be insulators and thus highly resistant to electrical charge. Using lasers, the team then placed quantum dots (QDs) of gold as small as three nanometers across on the tops of the BNNTs, forming QDs-BNNTs. BNNTs are the perfect substrates for these quantum dots due to their small, controllable, and uniform diameters, as well as their insulating nature. BNNTs confine the size of the dots that can be deposited.
In collaboration with scientists at Oak Ridge National Laboratory (ORNL), they fired up electrodes on both ends of the QDs-BNNTs at room temperature, and something interesting happened. Electrons jumped very precisely from gold dot to gold dot, a phenomenon known as quantum tunneling.
“Imagine that the nanotubes are a river, with an electrode on each bank. Now imagine some very tiny stepping stones across the river,” said Yap. “The electrons hopped between the gold stepping stones. The stones are so small, you can only get one electron on the stone at a time. Every electron is passing the same way, so the device is always stable.”
Yap’s team had made a transistor without a semiconductor. When sufficient voltage was applied, it switched to a conducting state. When the voltage was low or turned off, it reverted to its natural state as an insulator.
Furthermore, there was no “leakage”: no electrons from the gold dots escaped into the insulating BNNTs, thus keeping the tunneling channel cool. In contrast, silicon is subject to leakage, which wastes energy in electronic devices and generates a lot of heat.
Other people have made transistors that exploit quantum tunneling, says Michigan Tech physicist John Jaszczak, who has developed the theoretical framework for Yap’s experimental research. However, those tunneling devices have only worked in conditions that would discourage the typical cellphone user.
“They only operate at liquid-helium temperatures,” said Jaszczak.
The secret to Yap’s gold-and-nanotube device is its submicroscopic size: one micron long and about 20 nanometers wide. ”The gold islands have to be on the order of nanometers across to control the electrons at room temperature,” Jaszczak said. “If they are too big, too many electrons can flow.” In this case, smaller is truly better: “Working with nanotubes and quantum dots gets you to the scale you want for electronic devices.”
The Latest Bing News on:
Transistors without Semiconductors
- Biasing That Transistor Part 4: Don’t Forget The FETon November 9, 2020 at 4:00 pm
It would however be improper to round off the series without also admitting that bipolar transistors are only ... purposes has a piece of N-type semiconductor with source and drain connections ...
- TI introduces industry's first automotive GaN FET with integrated driver, protection and active power managementon November 8, 2020 at 11:04 pm
As a result, engineers are being challenged to design compact, lightweight automotive systems without compromising ... "Wide-bandgap semiconductor technologies like GaN inherently bring firmly ...
- TI introduces industry's first automotive GaN FET with integrated driver, protection and active power managementon November 8, 2020 at 10:01 pm
Texas Instruments today expanded its high-voltage power management portfolio with the next generation of 650- V and 600- V gallium nitride field-effect transistors for automotive and industrial ...
- Intel’s success came with making its own chips. Until nowon November 6, 2020 at 11:52 pm
The Silicon Valley pioneer long held it had to build its flagship chips in its own factories; then it hit the wall and is considering outsourcing—a milestone in the story of America’s losing its manuf ...
- Retrotechtacular: Old Transistorson November 6, 2020 at 4:00 pm
Beyond that, mass production of semiconductor material was ... It is possible to build a lot of things today without ever handling a discrete transistor. However, a modern integrated circuit ...
- Two dimensional semiconductor shows logic-in-memory promiseon November 6, 2020 at 4:19 am
Molybdenum disulphide two-dimensional semiconductor memory transistors are possible ... By scrolling to the bottom of this page EPFL has the paper available in full without payment.
- Semiconductors Enable Human-Like Learning in Robotson November 4, 2020 at 4:00 pm
Researchers in Germany have made advancements to achieve this with the development of an artificial neurotransistor that can imitate how brain neurons function—storing and processing information at ...
- A New Multimodal Architecture Said to Redefine the Way Transistors Workon November 2, 2020 at 9:40 am
Researchers at the University of Surrey have come up with a new type of transistor that offers linear behavior ... Like a conventional MOSFET, the source and drain are separated by semiconductor ...
- GBT Commenced Design Productivity Software Solutions Developmenton November 2, 2020 at 3:00 am
(GLOBE NEWSWIRE) -- GBT Technologies Inc. (OTC PINK: GTCH) (“GBT”, or the “Company”) announced that GBT together with Alpha EDA (“Alpha”), its joint venture partner, have developed IC design ...
The Latest Google Headlines on:
Transistors without Semiconductors
The Latest Bing News on:
- Beyond Bengaluru: Karnataka To Decentralise Growth And Take Innovation, Tech Ecosystem To Tier II Citieson November 13, 2020 at 2:52 am
While for years, Bengaluru had been the only focus of investors as well as the government, a new initiative ‘Beyond Bengaluru’ has been launched as part of the Bengaluru Tech Summit yesterday (12 ...
- Microsoft 365 and Office 2019 updates arrive with Apple Silicon and Big Sur supporton November 12, 2020 at 2:35 pm
The latest Microsoft 365 and Office 2019 updates make the productivity suite fully compatible with macOS Big Sur and Apple Silicon — but it is not native code for the M1 processor.
- Apple's latest MacBooks and Mac Mini run on a brand new, smartphone-like Apple Silicon M1 processor — here's why that matterson November 12, 2020 at 8:13 am
Apple made some big changes under the hood and has some big claims about extra power and battery life with its new M1 chip.
- Microsoft adding support for Apple silicon to Office for Mac betaon November 11, 2020 at 4:40 pm
Microsoft has announced that it will be adding support for Apple silicon to its Office for Mac beta, but did not specify when it will be publicly released.
- Apple Silicon and the 5G opportunityon November 11, 2020 at 1:45 pm
Apple may have come out strong with its new Apple M1, the first notebook chipset of its own design, but there’s a conspicuous gap in the new MacBook Air and MacBook Pro 13: 5G connectivity.
- Black Woman Tech Founder Shows How Innovation Is Done In The Silicon Bayouon November 11, 2020 at 4:14 am
When VCs ignore diverse innovators, they hold back economic growth and prevent solving critical challenges. What’s more, they miss out on good investments.
- Apple Store down ahead of Apple Silicon Mac eventon November 10, 2020 at 3:14 pm
Hours ahead of the "one more thing" event that will feature Apple Silicon Macs, Apple has taken down the Apple Store.
- Silicon Valley Firm Joins Gulf Investors to Fund Tech Dealson November 9, 2020 at 6:00 pm
A Silicon Valley venture-capital firm is targeting cash-flush Middle Eastern investors to fund technology companies, all while scouting the Gulf for buying opportunities.
- Apple Silicon: Next big thing, or more of the same?on November 8, 2020 at 6:00 pm
Apple seems poised to unveil the first crop of Macs powered by in-house designed Apple Silicon processors. But will these bring something new to the table, or is this move mostly for Apple's benefit?
- Report: The first Apple Silicon Macs will be the MacBook Pro and Airon November 3, 2020 at 9:37 am
Apple will start the Mac’s transition to ARM-based Apple Silicon CPUs with three laptops—both 13-inch and 16-inch MacBook Pros and the 13-inch MacBook Air—according to a report today from Bloomberg’s ...